Renewable power: Germany’s energy gamble

An ambitious plan to slash greenhouse-gas emissions must clear some high technical and economic hurdles.

 

In an industrial warehouse on the outskirts of Stuttgart, the sooty past is shaking hands with Germany’s green-energy future. In one corner sits a relic destined for a museum: a cast-iron engine as big as a bus, which was used until the early 1970s to compress coal gas for lighting, cooking and heating. Nearby, a gleaming network of stainless-steel tanks uses electricity to create methane out of water and carbon dioxide.

This power-to-gas (P2G) pilot plant is the largest of its kind in the world, and the research behind it could help to propel Germany to the front of the race for cleaner energy. Developers of the €3.5-million (US$4.5-million) project say that the P2G technology is an ideal way to cope with the unreliable nature of solar and wind power. During sunny or breezy days, excess electricity can be used to make methane, which can be stored and then burned to generate power when the winds fail or the days turn dark.

The quest to develop P2G storage is part of Germany’s ambitious Energiewende, or energy transition, a long-term plan to clean up the country’s energy systems. Enshrined in law, the scheme aims to slash CO2 emissions by replacing fossil fuels with renewable sources of energy. Germany hopes to generate at least 35% of its electricity from green sources by 2020; by 2050, the share is expected to surpass 80% (see ‘Green growth’).

The Energiewende — the world’s most extensive embrace of wind and solar power as well as other forms of renewable energy — enjoys the support of all Germany’s political parties and most of the population. It will probably continue whatever the results of the national election in September. Other nations are watching keenly to see how the experiment proceeds, and whether they should follow the German lead. “Germany’s Energiewende can mobilize a global energy revolution,” says Harry Lehmann, executive chairman of the World Council for Renewable Energies, who is based in Dessau, Germany.

To reach its goal, Germany is currently investing more than €1.5 billion per year in energy research. One of its chief aims is to improve and build more storage systems, such as the Stuttgart P2G plant. Another is extending and strengthening the electricity grid to wire up remote wind turbines and countless small photovoltaic installations. The research programme also seeks to improve the efficiency of energy production from sunlight, wind and biomass, and to encourage people to reduce energy consumption.

Most experts in Germany agree that the technical hurdles are surmountable. “We don’t need technological leaps to accomplish theEnergiewende,” says Eberhard Umbach, president of the Karlsruhe Institute of Technology, who oversees the €500-million energy-research activities of Germany’s national research centres.

But the economic challenges are daunting, with the total costs of the Energiewende estimated to top €1 trillion. Europe’s deep financial crisis looms large over a project of that scale, warns Roger Pielke Jr, an environmental-policy researcher at the University of Colorado Boulder. “The German public has so far shown great willingness to pay for the transformation, but there will be limits to that willingness, especially if the economic climate gets rougher.”

Money and power

The Energiewende is already visible to anyone travelling the German countryside. Expensive solar panels cover more than one million houses, farms and warehouses, thanks to generous subsidies. Along the motorways, clumps of wind turbines sprout on ridges, particularly in the breezy northern regions. The country’s green-energy portfolio is growing at a ferocious rate; last year, renewables supplied more than one-quarter of Germany’s gross electricity needs.

The primary motivation for the Energiewende is to combat climate change. By 2020, Germany aims to cut its greenhouse-gas emissions by 40% below 1990 production levels, and it hopes to achieve a reduction of at least 80% by 2050. The government set those goals in 2005, but the targets became much more ambitious in the aftermath of the Fukushima nuclear accident in Japan in March 2011.

That crisis spurred German Chancellor Angela Merkel to speed up a planned move away from nuclear power, which provided 25% of the country’s primary power in 2010. She closed eight nuclear plants immediately and pledged to shut the remaining nine by 2022. Suddenly, Germany needed to pick up the pace of its move towards renewable energy.

For German consumers, the costs of that shift are apparent in their monthly electricity bills. The statements include a litany of ‘shared costs’ that are split by all households to fund theEnergiewende — and result in some of the highest electricity prices in Europe. (Heavy industries are currently exempt from paying the surcharge.)

The shared costs are a mechanism for promoting green forms of energy, which are more expensive to produce than electricity from coal and natural gas. Germany’s Renewable Energy Act (EEG), the legal force behind the Energiewende, allows owners of solar panels and wind turbines to sell their electricity to the grid at a fixed, elevated price. Renewable-power producers cashed in an estimated €20 billion last year for electricity that was actually worth a mere €3 billion on the wholesale electricity market. The difference came out of the pockets of consumers.

The EEG, first passed in 2000, has helped Germany to install many more wind and solar power systems than most other developed nations. But the subsidies are causing some grotesque distortions in the electricity market — to the point at which energy companies are sometimes forced to sell conventional power at a loss.

The effects of Germany’s policies are also reverberating through the European energy market. One of Europe’s biggest energy providers, E.ON based in Düsseldorf, announced in January that it plans to close several gas-fired power stations across Europe that were operating at a loss, even though they are far less polluting than coal-fired plants. The “unmanaged growth” of renewable-energy sources is forcing gas-fired plants to spend too much time idle, E.ON boss Johannes Teyssen told shareholders.

At the same time, Germany is subject to the vagaries of outside forces, such as the rapid expansion of natural-gas production in the United States, which has curbed domestic demand for coal. Excess US coal is now heading to Europe, helping to fuel a resurgence of coal use in the United Kingdom and Germany, among other countries. With Germany’s imports of low-cost coal rising, the country’s greenhouse-gas emissions increased by almost 2% in 2012 — bucking a long-term decline. Last August, federal minister of the environment Peter Altmaier made clear that coal-fired plants will be needed “for decades to come” to ensure energy supplies. Germany is currently building some 11 gigawatts of coal-fired plants and its existing capacity of around 55 GW will not shrink as quickly as the country had planned.

The coal resurgence makes it unlikely that Germany will meet its 2020 emissions targets, says Pielke Jr. “You must accept the logic,” he says. “If you opt out of nuclear power, your near-term emissions will go up.”

But German officials say that even if emissions rise temporarily, that trend will turn around. State-of-the-art coal-powered plants, such as a new 2.2-GW facility near Cologne that burns lignite, or low-grade coal, will replace several older, less efficient plants. The net effect will be to reduce CO2emissions, says Altmaier.

To sustain that trend, however, the costs of green energy need to come down. “Subsidies have helped to get the renewable thing started, but sooner or later renewable energy must become economically self-sustaining,” says Brigitte Knopf, head of German and European energy strategies at the Potsdam Institute for Climate Impact Research.

That is where Germany is aiming many of its energy-research efforts, which will receive in excess of €3.5 billion from the government between 2011 and 2014. About €200 million is going towards developing and improving storage technologies.

“Renewable energy is a wonderful thing — provided you are able to store it at a large scale and distribute it efficiently,” says Frithjof Staiß, managing director of the Center for Solar Energy and Hydrogen Research (ZSW) in Stuttgart, which operates the P2G plant. By making renewable energy more manageable and marketable, advanced storage technologies can ultimately help to reduce the cost of wind and solar power, he says.

“Germany’s Energiewendecan mobilize a global energy revolution”

Germany currently stores excess electricity by using pumps to push water uphill into reservoirs. When electricity demand goes up, the water is released through turbines to generate hydroelectric power. But there are limits to expanding this type of storage. With 30 pump facilities already in operation, Germany has few suitable sites left for building more; the country plans to increase pump-storage capacity by just 20% by 2020.

P2G, however, could provide a vast amount of new storage capacity and Germany is leading the way. The plant in Stuttgart has 250 kilowatts of electrolysis stacks, which use electricity from renewables to produce hydrogen from water. To make methane, the hydrogen is reacted with CO2from decomposing sewage and agricultural waste at a nearby biogas plant. Other P2G plants could scrub CO2 from the air.

But P2G is still an immature technology, with high upfront costs and an efficiency of only about 50% in converting electricity to methane. Synthetic methane plants have also struggled with the purity of their product. At the ZSW facility, the main goal is to routinely produce gas with low oxygen and hydrogen content.

Several other government-funded research groups are working to improve the membranes used in electrolysis reactions to produce the hydrogen for P2G plants. Advanced proton-exchange membranes, for example, can respond to electricity fluctuations within milliseconds, which could produce the very pure hydrogen needed for P2G and other clean-energy technologies.

Once P2G plants work out such issues, they could scale up, and synthetic gas could go directly into the network of pipelines and storage tanks currently used for natural gas. It could then be burned in power plants to produce electricity; by some estimates, this technology will be able to store up to 500,000 gigawatt-hours of electricity, enough to power Germany for more than six months.

The synthetic gas could be also used for heating or as a vehicle fuel. This prospect has piqued the interest of the car-maker Audi, which is currently building the first commercial P2G test facility in Werlte, northern Germany. The facility is expected to produce up to 4,000 cubic metres of synthetic methane per day — enough to fuel about 1,500 cars. Audi is also set to introduce a hybrid natural-gas-powered sedan later this year.

If Germans embrace this kind of vehicle, it could help to cut carbon emissions from the transport sector, which has lagged behind others in implementing the Energiewende. The government intends to have one million battery-powered cars on German roads by 2020, but experts view that goal as unrealistic. The industry lacks the capacity to produce that many electric cars, and motor-loving Germans have not shown much desire for them. The new Audi and similar models may turn more heads, because consumers can switch to normal fuel if they are running low on natural gas and cannot find a specialized refuelling station. That option is not available to owners of batter-powered vehicles that run low on charge.

 

Continue reading…..

Share

You may also like...

Leave a Reply

Your email address will not be published. Required fields are marked *


*